Effect of redispersible polymer powders on some properties of mortars with complex mineral additives
https://doi.org/10.21822/2073-6185-2024-51-4-217-225
Abstract
Objective. To identify patterns in changes in the properties of building mortars obtained from dry building mixtures (DBM) depending on the dosage of redispersible polymer powders (RPP), the composition of the complex mineral additive (CMA) and the duration of hardening in air-dry conditions. Method. The studies were conducted in accordance with the regulatory documents: GOST 31356–2013 Dry building mixtures on a cement binder. Test methods. GOST R 58277-2018 Dry building mixtures on a cement binder. GOST 31108-2016 Test methods, general construction cements. Specifications. Result. The presence of RPP in the composition of DBM leads to an increase in the flexural strength when kept for up to 120 days in air-dry conditions and an increase in the adhesion strength to the base. The greatest adhesion strength is observed in compositions with fly ash. The introduction of RPP and the composition of the MKD have an insignificant effect on increasing the modulus of elasticity. A positive effect of RPP in increasing the flexural strength limit during prolonged hardening of the mortar in air-dry conditions was revealed. The effect of RPP on the rate of hardening of the mortar at an early age was noted. Conclusion. Replacing part of the natural mineral raw materials with technogenic waste and using RPP will increase the environmental and economic efficiency of the production of SSS and ensure the production of mortars with the required properties.
About the Authors
G. N. Nesvetaev
Don State Technical University
Russian Federation
Russian Federation
Grigory V. Nesvetaev, Dr. Sci. (Eng.), Prof., Department of Construction Production Technology
1 Gagarin Square, Rostov-on-Don 344003
G. N. Hadzhishalapov
Daghestan State Technical University
Russian Federation
Russian Federation
N. Kh. Gadzhimagomed, Dr. Sci. (Eng.), Prof., Head of the Department of Technology and Organization of Construction Production
70 I. Shamil Ave., Makhachkala 367015
I. A. Zhivotkova
Daghestan State Technical University
Russian Federation
Russian Federation
Irina A. Zhivotkova, Postgraduate Student, Department of Construction Production Technology and Organization
70 I. Shamil Ave., Makhachkala 367015
References
1. Panchenko A.I. Dry mixes in Russia: features of production and application. Construction materials. 2002;5: 19-22. (In Russ)
2. Zagorodnyuk L.Kh., Gridchin A.M., Lesovik V.S. Trends in the development of dry construction mixes production in Russia. Bulletin of the Belgorod State Technological University named after V. G. Shukhov. 2016;12: 6-14. DOI: 10.12737/22638. (In Russ)
3. Kuzmina V.P. Protection and repair of reinforced concrete structures. Dry construction mixes. 2017; 2:. 23-25. (In Russ)
4. Korovkin M.O., Korotkova A.A., Eroshkina N.A. Repair dry building mixes for restoring the geometric characteristics of reinforced concrete structures. Education and Science in the Modern World. Innovations. 2020;5 (30):122-128. (In Russ)
5. Loganina V.I. Dry building mixes for the restoration of historical buildings. Regional Architecture and Construction. 2015; 3 (24): 34-42. (In Russ)
6. Kaklyugin A.V., Bobrova V.V., Valov M.P., Shcherbakova V.S. Use of sludge from chemical water treatment of thermal power plants in the production of building materials and products . Young researcher of the Don. 2020; 4 (25):28-33.
7. Nesvetaev G.V., Kozlov A.V., Kozlov G.A., Filonov I.A. Influence of some mineral additives on the properties of fine-grained concrete. Engineering Bulletin of the Don. 2022;11 URL: ivdon.ru/ru/magazine/archive/n11y2022/7972. (In Russ)
8. Prokopski G., Huts A., Marchuk V. Granite dust as a mineral component of a dry cement mortar mixtures. Archives of Civil Engineering. 2020; 66(3): 81-96. DOI: 10.24425/ace.2020.134385.
9. Kuzmina, V.P. Fillers for dry building mixtures. Dry building mixtures. 2017; 3: 8-15. (In Russ)
10. Belov, V.V., Obraztsov I.V. Calculation of dense packings of particles in mixtures of finely dispersed components. Dry building mixtures. 2014; 3: 32-35. (In Russ)
11. Salamanova M.Sh., Ismailova Z.Kh., Okueva P.Kh., Eskiev M.S. Analysis of methods for compiling recipes for modified dry building mixtures. Grozny Natural Science Bulletin. 2017; 4(8): 67-72. (In Russ)
12. Vasilik P.G., Golubev I.V. Review of modern cellulose ethers of the Mecellose trademark for cementbased tile adhesives. Dry building mixtures. 2012;1:18-21. (In Russ)
13. Manushina A.S., Urbanov A.V., Akhmetzhanov A.M. et al. Influence of mineral and polymer additives on the properties of tile adhesive. Dry building mixes. 2016; 2:17-20. (In Russ)
14. Lesovik V.S., Zagorodnyuk L.Kh., Kuprina A.A. et al. Effective masonry mortars for autoclaved wall materials. Construction materials. 2016;12: 22-25. (In Russ)
15. Alaskhanov A.Kh., Salamanova M.Sh., Bisultanov R.G., Yusupov S.S. Theoretical aspects of obtaining dry building mixtures based on natural resources of the Chechen Republic. Theoretical foundations for creating effective composites: Collection of materials of the Russian online conference dedicated to the Day of Science. Belgorod: Belgorod State Technological University named after V.G. Shukhov. 2018; 12-17. (In Russ)
16. Nesvetaev, G.V., Osipov V.V. Adhesion strength of modified building mortars to various bases depending on curing conditions. Engineering Bulletin of the Don.2023;4 ivdon.ru/ru/magazine/archive/n4y2023/833. (In Russ)
17. Babkov V.V., Chuikin A.E., Sinitsyn D.A. et al. Study of the properties of modified plaster compositions applied at negative temperatures to autoclaved aerated concrete blocks. Dry building mixtures. 2012; 4:. 15-18. (In Russ)
18. Nesvetaev G.V., Zhivotkova I.A. Influence of some mineral additives on the properties of fine-grained concrete and mortars. Engineering Bulletin of the Don, 2024;5 ivdon.ru/ru/magazine/archive/n5y2024/9200
19. Nesvetaev G.V., Osipov V.V. On the influence of redispersible polymer powders on the modulus of elasticity and adhesion strength of mortars. Engineering Bulletin of the Don. 2022; 7(91). (In Russ)
20. Belykh S.A., Kudyakov A.I., Chikichev A.A. Dry building mixture with increased adhesive strength for finishing brick surfaces in wet rooms. Bulletin of Tomsk State University of Architecture and Civil Engineering. 2017; 1 (60):122-133. (In Russ)
21. Narin S.Yu., Kronshtatov A.P. CONCOLIT BARS repair mortars for strengthening and restoring concrete structures and buildings. Special cements for concrete. Dry building mixtures. 2011; 6:13-15. (In Russ)
Review
For citations:
Nesvetaev G.N., Hadzhishalapov G.N., Zhivotkova I.A. Effect of redispersible polymer powders on some properties of mortars with complex mineral additives. Herald of Dagestan State Technical University. Technical Sciences. 2024;51(4):217-225. (In Russ.) https://doi.org/10.21822/2073-6185-2024-51-4-217-225
Views:
85
Email this article 
