Coupling of reinforcement with Tuff concrete on quartz sands prepared on Portland cement without additives and with expanding additives
https://doi.org/10.21822/2073-6185-2022-49-2-94-102
Abstract
Objective. The study of the adhesion of reinforcement with tuff concrete on quartz sands, prepared both on ordinary Portland cement and expanding additives.
Method. The solution is carried out by conducting an experiment, for this purpose, the manufacture and testing of tuff-concrete prisms with one centrally located reinforcing rod of a periodic profile of class A-400 was carried out, within the time limits established by the norms.
Result. According to the results of the experiment, it was found that the adhesion of reinforcement to concrete is mainly determined by the compressive strength of concrete. The strength of the reinforcement's adhesion to concrete increases with the increase in the strength of concrete. In the studied compositions, the effect of the concentration of a large (tuff) filler or an expanding additive was not detected.
Conclusion. The adhesion of reinforcement to concrete is largely determined by the strength of the concrete itself. The type of binder (the presence of an expanding additive) and the concentration of coarse aggregate do not significantly affect the adhesion of reinforcement to concrete. The dependence between the coupling of reinforcement during punching and the strength of concrete is revealed. An assessment (indirect) of the endurance and crack resistance of the coupling can be given by (the value of the conditional coupling) lsl, determined by the length of the visually visible cut of the consoles on concrete samples during penetration tests. In tuff-concrete of the studied compositions, the lcl decreases with an increase in the strength of concrete. In tuff concrete with RD, the endurance and crack resistance of the coupling turned out to be higher compared to tuff concrete on ordinary Portland cement.
About the Authors
B. H. Beshtokov
H.M. Berbekov Kabardino-Balkarian State University
Russian Federation
Russian Federation
Cand. Sci. (Eng.), Assoc. Prof.; Department of Construction Production,
173 Chernyshevsky Str., Nalchik 360004
A. S. Tsipinov
H.M. Berbekov Kabardino-Balkarian State University
Russian Federation
Russian Federation
Senior Lecturer, Department of Construction Production,
173 Chernyshevsky Str., Nalchik 360004
A. M. Gusenov
Daghestan State Technical University
Russian Federation
Russian Federation
Postgraduate Student, Department “Technology and organization of construction production,
367026, Makhachkala, Imam Shamil Ave., 70
A. R. Kazharov
H.M. Berbekov Kabardino-Balkarian State University
Russian Federation
Russian Federation
Senior lecturer of the Department of Construction Production,
173 Chernyshevsky Str., Nalchik 360004
A. A. Cardanov
H.M. Berbekov Kabardino-Balkarian State University
Russian Federation
Russian Federation
Postgraduate Student, Department of Construction Production,
173 Chernyshevsky Str., Nalchik 360004
References
1. Gvozdev A. A. Structures of concrete and some features of its mechanical qualities.Proceedings of the NIIZHB. Strength, structural changes and deformations of concrete. M., 1978: 121-123. (In Russ)
2. Gvozdev A.A., Dmitriev S.A., GushchaYu.P., Zalesov A.S., Mulin N.M., Chistyakov E.A. New in the design of concrete and reinforced concrete structures. Edited by Doctor of Technical Sciences prof. A.A. Gvozdev. M. Stroyizdat 1978: 209. (In Russ)
3. Mailyan R.L. Akhmatov M.A. Reinforced concrete on porous stone waste. M., Stroyizdat, 1987: 208. (In Russ)
4. Mulin N.M., On the study of reinforcement coupling with concrete. Methods of laboratory studies of deformations and strength of concrete reinforcement and reinforced concrete structures. Proceedings of the coordination meeting. Edited by Candidate of Technical Sciences V.V. Makarichev. Academy of Construction and Architecture of the USSR, NIIZhB, M.1962:124-137. (In Russ)
5. Oatul A.A. Fundamentals of the theory of reinforcement coupling with concrete. "Research on concrete and reinforced concrete", Proceedings of the Chelyabinsk Polytechnic Institute Chelyabinsk, 1967; 46:6-26. (In Russ)
6. Piradov A.B. Constructive properties of light concrete and reinforced concrete, M., Stroyizdat. 1973: 124. (In Russ)
7. Strength, structural changes and deformations of concrete. Ed. Gvozdeva A.A. M., Stroyizdat 1978: 299. (In Russ)
8. Kholmyansky M.M. Method of experimental study of reinforcement coupling with concrete. Methods of laboratory studies of deformations and strength of concrete reinforcement and reinforced concrete structures. Proceedings of the coordination meeting. Edited by Candidate of Technical Sciences V.V. Makarichev. Academy of Construction and Architecture of the USSR, NIIZhB, M. 1962: 138-147. (In Russ)
9. Tsekhmistrov V.M. Calculation of stresses and deformations when pulling rebar from a concrete prism supported by an end face (a sample for pulling out.) "Research on concrete and reinforced concrete", proceedings of the Chelyabinsk Polytechnic Institute No. 46, Chelyabinsk, 1967:.27-43. (In Russ)
10. Waltz K., Vishers G. Structural high–strength lightweight concrete. 81 p. (In Russ)
11. Akhmatov M.A. The use of stone-sawing waste of tufokarriers and loose porous rocks as fillers of light concrete and structures made of them. Nalchik, 1981: 128. (In Russ)
12. Akhmatov M.A. The effectiveness of the use of building materials and concrete. Nalchik "Elbrus" 1986: 160. (In Russ)
13. Akhmatov M.A. Stone waste and loose materials as raw materials for the production of porous aggregates, light concrete and structures made of them. Concrete and reinforced concrete in the third millennium. International Scientific and Technical Conference. Rostov-on-Don 2000: 40-49. (In Russ)
14. Akhmatov M.A. The effectiveness of the use of light concrete and reinforced concrete structures on aggregates from stone waste and loose porous rocks of volcanic origin.: Diss. ... Doctor of Technical Sciences 05.23.01, 05.23.05- Rostov-on-Don 1999: 514. (In Russ)
15. Akhmatov M.A. The effectiveness of the use of light concrete and reinforced concrete structures on aggregates from stone waste and loose porous rocks of volcanic origin.: Abstract diss. ... Doctor of Technical Sciences 05.23.01, 05.23.05- Rostovon-Don 1999: 59. (In Russ)
16. Nesvetaev G.V. Regularities of deformation and prediction of concrete resistance under force and temperature influences: Abstract diss. ... Doctor of Technical Sciences: 05.23.05. Rostov-on-Don 1998. (In Russ)
17. Nesvetaev G.V., Efremova I.A., Egorochkina I.O. To concrete quality management by regulating the properties of the contact zone. [Stroitelʹnyye materialy, izdeliya i konstruktsii na rubezhe vekov] Building materials, products and structures at the turn of the century. Rostov-on-Don 1999: 28-30. (In Russ)
18. Nesvetaev G.V., Timonov S.A. Shrinkage deformations and earlier cracking of concrete. [Pyatyye akademi-cheskiye chteniya RAASN] Fifth Academic Readings of the Russian Academy of Sciences. Voronezh. 1999: 305-310. (In Russ)
19. Nesvetaev G.V., Chmel G.V. Some properties of expanding cements and concretes based on them . [Beton i zhelezobeton v tretʹyem tysyacheletii. Mezhdunarodnaya nauchno-prakticheskaya konferentsiya] Concrete and reinforced concrete in the third millennium. International Scientific and Practical Conference. Rostov-on-Don 2000: 271-276. (In Russ)
20. Simonov M.Z. Concrete and reinforced concrete on porous aggregates. M., Stroyizdat. 1955: 254. (In Russ)
21. Simonov M.Z., Shaginyan S.G. The use of natural porous aggregates in the production of concrete and reinforced concrete. [Beton i zhelezobeton] Concrete and reinforced concrete. 1985; 7: 6-7. (In Russ)
Review
For citations:
Beshtokov B.H., Tsipinov A.S., Gusenov A.M., Kazharov A.R., Cardanov A.A. Coupling of reinforcement with Tuff concrete on quartz sands prepared on Portland cement without additives and with expanding additives. Herald of Dagestan State Technical University. Technical Sciences. 2022;49(2):94-102. (In Russ.) https://doi.org/10.21822/2073-6185-2022-49-2-94-102
Views:
259
Email this article 
